2005 ford five hundred transmission recall

I thought only mini-cars (Subaru Justy) used them. Ford / five hundred / 2005; The 2006 ford five hundred has air conditioner and heating problems. The contact owns a 2005 Ford Five Hundred sel. I hadn't considered that, I'll definitely look into it. DANNY L. EXPERT. Too bad he doesn't know what goes on in his own service dept! If I was in your position, I would also want a new transmission, but I doubt that you will be able to sway Ford in their decision regarding how to resolve the problem. 2005 Ford Five Hundred suddenly had transmission problem just over 40,000 miles. In some cases, the transmission would fail completely, leaving the driver stranded. to illuminate and could have limited to no throttle response. Edit: Reading more, it seems noise from the trans is possible as they are going bad. However from that point on, the transmission worked well until I sold the Aerostar 100,000 miles later. Car hesitates when downshifting at 25 and 35 mph once it is heated up (212F or higher per TSB). Sorry man, new car time. The vehicle was towed to the dealer where they diagnosed that the throttle bottle needed to be replaced. This was at ~146,000 miles, but there is only ~48,000 miles on the transmission itself. all problems of the 2007 Ford Five Hundred When I turn the steering wheel to the right, or when I go over a bump or pot hole, the car makes a grinding/squealing noise that seems located at the left rear end. Transmission went, had the vehicle towed to dealer. Not trustworthy to drive. No matter what the dealership wants to do, the ultimate decision will be made on the corporate level. Binding of the shifter slider can make the transmission shifter difficult to move. TrueDelta is not affiliated with any car manufacturer or their trademarks. Had a mechanic check it and he said that there were bubbles in the steering pump and that the oil was pink instead .. 2005-2007 FORD FIVE HUNDRED TRANSMISSION VALVE BODY COVER PAN OEM 269229 (Fits: 2005 Ford Five . Sometimes jamming of gear shift at park position required some mechanical replacement. Given that I have either purchased or leased 6 vehicles from this dealership in the past 17 years, I am going to ask them to advocate a replacement with Ford on my behalf. @media(max-width: 960px) { .adt {.. Hi there, so every time I turn my steering wheel, there is a groaning and sometimes clunking noise(especially when in idle). from 30 MPH to 50 MPH, Computers updated, but the problem still exists and is worse, if anything, replaced valve body on transmission which eliminated Clear DTCs. Anyway, I'll update once we get the codes and everything! While driving approximately 30 mph, the vehicle failed to shift into gear and became inoperable. 2005 ford five hundred. The passenger side half shaft was replaced under warranty. . At a stop light it stalled, and I managed to get it running again, did a u-turn and got it home. Since then I've experienced transmission problems with no code alert. *tgw the consumer also stated the rpm's would race at times. Note: this does not affect the temperature of the air that comes from the vents, it affects the amount of air that comes from the vents. document.getElementById( "ak_js_1" ).setAttribute( "value", ( new Date() ).getTime() ); Ford Fusion Losing Power When Accelerating, Air Conditioner Stops Blowing When Accelerating, 1996 Ford F-150 Transmission 4-Speed Automatic, 2005 Ford Explorer Check Transmission Light, 2019 Mustang 10 Speed Transmission Problems, 5 Best Bed Liners for Ford F150: Protect Your Trucks Bed with These Heavy-Duty Options. On lower mileage vehicles, upgrading the software in the Here is the information you requested. 2006 Ford Five Hundred 100,000 mi, Visitor. The vehicle was not repaired. Engine not reving or remaining at idle when you press throttle would be something else. Privacy Policy | Terms and Conditions | Copyright Policy. 2005 Redesign Year. Park the vehicle directly in front of a wall or screen on a level surface, approximately 25 feet (7.6 meters) away. Local repair shop scanned vehicles repair codes, determined it to be a transmission failure. Need advice about a specific Ford Five Hundred problem? The car careened off the road and into a tree, killing the woman and injuring her daughter. The contact owns a 2005 Ford Five Hundred sel. Recall List for the 2005 Ford Five Hundred Official recalls have been issued for the 2005 Ford Five Hundred by the NHTSA. I have a 2005 Ford 500 with the 6 speed auto trans, 70,000 miles. I have a 2005 Ford 500 and the air bag indicator some times flashes on and off or comes on and stays on. Have they come up with any improvements to this trans given that it seems to be regarded with low-esteem? If your transmission is running low on fluid, be sure to add some - find out how to do this here! Trans quit. Tuesday,.. 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 96, 000 MILES, 2005 FORD FIVE HUNDRED, 4 CYL, 2WD, AUTOMATIC, 100, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 120, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 60, 000 MILES, 2005 FORD FIVE HUNDRED, 3.0L, 6 CYL, 2WD, AUTOMATIC, 125, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, AWD, AUTOMATIC, 56, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, AWD, AUTOMATIC, 94, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, FWD, AUTOMATIC, 26, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 2WD, AUTOMATIC, 85, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 2WD, AUTOMATIC, 63, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 43, 000 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, 2WD, AUTOMATIC, 175, 000 MILES, 2005 FORD FIVE HUNDRED, 3.0L, 6 CYL, 2WD, AUTOMATIC, 156, 700 MILES, 2005 FORD FIVE HUNDRED, 6 CYL, AUTOMATIC, 155, 000 MILES, 2005 Ford Five-Hundred Harsh or Delayed Shifting of Automatic Transmission, 2005 Ford Five-Hundred Wrench Light, Service Engine Soon Light, Possible Poor Throttle Response, 2005 Ford Five-Hundred Rear Brakes Wear Out Abnormally Fast, 2005 Ford Five-Hundred Slipping and Hard Shifts from Automatic Transmission, 2005 Ford Five-Hundred Transmission Shifter is Hard To Move, 2005 Ford Five-Hundred Coolant Leakage from Heater Core, Possible Leakage onto Passenger Side Foot Well, 2005 Ford Five-Hundred Blower Motor Only Works on High, 2005 Ford Five-Hundred A/C Fan Speed Changing Constantly, Ford Five Hundred 2005 Ford 500 Door Handles, Ford Five Hundred Where The ECT Is Locater In Ford 500 3.0 2005, Ford Five Hundred 2005 Ford 500 F2 Fuse Blows Instantly, Ford Five Hundred Ford 500 2005 Water Pump, Ford Five Hundred 2005 Ford 500 Power Steering Groan Noise, Ford Five Hundred Steering Column Makes Rubbing Noise When Hot, Ford Five Hundred 2005 Ford 500 Temp Is Irradic At Best. I really need to get this running and all the help I can get is greatly appreciated. To restart, must shut car off, key out and it will restart. Open the Hood - How to pop the hood and prop it open. Free shipping on . The transmission, air compressor, and throttle. problems related to transmission failure (under the power train category). Complex repairs are typically those that are very difficult to fix and may require the replacement of major parts. The Limited . Posted on Nov 01, 2010. The resistor is normally found behind the glove box, next to the blower motor. The vehicle was coasted down an incline and then the transmission began to operate normally. Problems with 2005 Ford Five Hundred Hi there, I'm having some problems with my 2005 Ford Five Hundred (6 speed automatic). May not be able to get parts. The transmission was replaced successfully. This is a well documented problem, and is caused by a failing blower motor resistor. The recall affects certain Chevrolet, Buick, GMC, and Cadillac models from the 2014 and 2015 model years. I had approximately 1/4 tank of gas in my car when the fuel cap warning light came on. When driving in hot weather for awhile the steering column makes a rubbing noise. Have 10 days left on my 60 day warranty. I have checked the steering fluid and it is at maximum level. 2005 Ford Five Hundred automatic Transmission Options:AT, (3.0L), CVT (trans code A on certification label), AWD. breadcrumb. 4. A cylinder head had a crack and in stripping down the engine, the service manager reported that a cylinder wall was scored and the entire engine would be replaced (this was also under warranty). wrench and check engine light on little or no throttle response. Every Ford Five Hundred comes with a 3.0-liter V6 rated for 203 horsepower and 207 pound-feet of torque. Re: 2005 500 transmission problem. Description: Used 2005 Ford Five Hundred SE with AWD, Keyless Entry, Bucket Seats, Alloy Wheels, 17 Inch Wheels, Cloth Seats, and Independent Suspension 2005 Ford Five Hundred SEL newly listed Price: Call for Price No Accident or Damage Reported 3+ Owners Multiple Use Service History Dealer: Van Devere Auto Outlet Location: Akron, OH Used: More Details Email This Quote. Worst 2005 Ford Five Hundred. Hello, I'm Danny. 2005 Ford Five Hundred Engine not specified 91000 mi US $2000 Car hesitates when downshifting at 25 and 35 mph once it is heated up (212F or higher per TSB). No previous transmission issues, and I take very good care of the car, with recent dealer maintenance. If you've replaced your Ford electronic throttle body or you've disconnected the battery, you must do a Ford throttle body relearn to establish a new baseline idle. Engine and trans ramped great together. I called the Ford care line to report it, but they claim they are unaware of any issues. However, the CVT used in the Ford Five Hundred and Mercury Montego was prone to failure, with the transmission slipping or jerking without warning. This may not illuminate the I took the car to a m.. Visitor. I have always purchased American made cars, but for the price and to have these issues arrive and not hold FORD accountable is simply disheartening.that they will not take full responsible to replace this part that has cause so many dissatisfied customers. Worried about potential repair costs? The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance. The manufacturer of the transmission, which is a third party, has issued many software updates, but when these updates fail to correct concerns, the transmission must be removed, disassembled, inspected, and repaired. If you have a recalled transmission, do not drive your car until it has been repaired by a qualified mechanic. The recall was issued after reports surfaced that the transmission could fail without warning, leaving drivers stranded. radiator statistics and reliability analysis of Ford Five Hundred based on all problems reported for the Five Hundred. eBay; eBay Motors . I would NOT be owning this car 12 months from now. Check out our Ford Five Hundred overview to see the most problematic years, worst problems and most recently reported complaints with the Five Hundred. What is the correct fuel pressure or is the pressure sensor.. These forums have helped make our results possible. It turned off again. I just purchased an 2005 Five Hundred with 5000 miles on it. Corroded or deteriorated parts should be replaced, and the coolant should be flushed. Took it to the Ford dealership and am told it'll cost $7,000 to replace the CVT. Consumer writes in regards to hard shifting and two instrument panel lights illuminating. . My concern is this third transmission will also fail at some point. Looks like direct drive on this 3.0 motor seems to have a tiny dripple under it The way you describe it, sounds like an electronic throttle problem - but I don't know what this car has. We review every problem as we work to keep our roads safe. Sign up for alerts and we'll. Also caught leak on back axle on top of rear transaxle. 2005-2007 FORD FIVE HUNDRED TRANSMISSION VALVE BODY WIRING HARNESS OEM 269232 (Fits: Ford Five . may break down before the transmission is taken out of service. The 2005-2007 Ford Five Hundred with automatic climate control may have a problem with frequent fan speed changes when using the heater or air conditioner. If you have a car affected by the recall, you will need to take it to a dealership or authorized repair facility to have the transmission repaired. Tons of room inside and the trunk is huge. For example, a simple repair such as fixing a small leak in a pipe may only take a few minutes. The gas mileage isn't that good but it's a 2005. Vehicle behaved as if stuck in "low gear" (CVT) "check trans" displayed on info screen after restart. I don't remember the exact mileage but it's between 85-90,000 when I bought it it had around 65,000 Oh and it's an 07 SEL AWD That seems to help. I can hit the gas pedal and get the car up to 80 and let the car ease back down to 55 and the RPM's will at 1500 RPM's. A couple of days ago I took the throttle body off and used SeaFoam Throttle Body Cleaner and used a old tooth brush to clean it. After he unplugged it , the car had no issues . Transmission Problems February 25: Ford Recalls Vehicles Over Loose Transmission Bolts 2005 Ford Five Hundred Transmission Problems 2005 Ford Five Hundred Transmission. Images (Click to enlarge) SPONSORED LINKS. They took it apart and put it back together and said all is well. The codes he got when he did a reading were P0420, P0304, & P0300. 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus) Page 57 The horizontal edge of the brighter light should touch the horizontal reference line. 2005 Ford Five Hundred automatic Transmission Options:AT, (3.0L), 6 speed . Description of the Complaint: 2005 fore five hundred- the following problems have occurred; 1)four times the check transmission light has come on , and car then was unable to drive faster than 40 mph. At the next red light I just turned the car off for 5-10 seconds and started it again. Did NOT solve problem. The exhaust manifold is slightly above it, so be careful not to burn yourself. The consumer went to her local dealer and a diagnostic's test revealed a problem with the PCV valve. In some instances, the failure has been attributed to the sealed-for-life nature of the transmission, as the awd malfunction and skid light on,but can reset malfunction. This can happen without warning and can increase the risk of a crash. I own a 2005 Ford 500 with a headlight issue. 2005. . Asim brand transmission began malfunctioning (hard shifting) at 88,000 miles. The complete details of all recalls are listed below, along with. Kmj. More Info. .. No recent transmission fluid or filter changed 5. Check Engine Light Return to top 2005 Ford Five Hundred 4dr Sedan Transmission and engine lights still come on, and transmission is sluggish. related to trouble-codes, p-codes-powertrain, p0100-p0199, p0193, related to fuel-system, fuel-pump, fuel-pressure, related to engine-cooling, coolant-temperature-sensor, replace-remove, related to engine-cooling, water-pump, replace-remove, related to exhaust, catalytic-converter, replace-remove, related to suspension, sway-bar, link, replace-remove, related to exterior-light, headlight, wiring, related to warning-lights, oil-life-reset, related to exterior-light, turn-signal, not-working. Why in gods name is nobody doing something about this problem. If you have a transmission problem, you may have a code set in the P0700 range. It was running totally fine before this, but yesterday I was driving down the highway and noticed that the revs were acting up a little bit. I'm a long-time Ford and automotive enthusiast, and I've been writing about cars for over 10 years. Or possibly an air leak. Free shipping for many products! Asim brand transmission began malfunctioning (hard shifting) at 88,000 miles. My experience with Ford on major warranty problems is that they seemed to do what was right. But it still had the jerking problem. We are 103,000+ car owners sharing real-world car information. 2022, CarProblemZoo.com All rights reserved. ENGINE AND ENGINE COOLING:ENGINE Date Reported APRIL 01, 2007 NHTSA Reference #10022241 2005 Ford 500, 6cyl sending code PO193, after making an adapter to connect fuel pressure gauge found that fuel pressure stays at 30 lbs. I am still experiencing slippage in the transmission when going from 0-35; at which point the vehicle will LURCH FORWARD! If that doesn't fix it I might look at the plugs and wires . I hope that you find everything you need on our website and that we can help guide you through all your automotive needs. Paint, Rust, Leaks, Rattles, and Trim (3%). If your battery has green or white cruddy deposits, it is probably not getting enough juice from and will likely wear out sooner, If your car is leaking a small amount of power steering fluid - see this video on how to fix the leak. Has anyone had this problem or is it a characteristic of the car,or. There have been a few high-profile cases in the news lately of people driving with recalled transmissions. If you own a 2005-2006 Ford Five Hundred or Mercury Montego with a CVT, be sure to schedule an appointment with your local Ford dealer to get the software update. . The Ford 500 CVT transmission recall affects over 12,000 vehicles from the 2006 and 2007 model years. Worried about potential repair costs? Privacy Policy | Terms and Conditions | Copyright Policy. consumer writes in regards to hard shifting and two instrument panel lights illuminating. Then it starts idling really rough, and when I put it into drive, it gets really iffy and starts lurching, similar to how a standard would if the clutch was let out too early. 2005 Ford Five-Hundred Harsh or Delayed Shifting of Automatic Transmission The automatic transmission may develop shifting concerns. The failure occurred five times. PS fluid is at operating level to m.. Everything is quiet and normal when the car is cool, but after it heats up there is a loud whining noise whenever I turn the steering wheel. $22,840 to $26,640 Price range The price range shown is the range of price from low to high of all matching vehicles listed on CarGurus right now. If it is, you should take it to a Ford dealer to have the CVT replaced. New Transmission required. Keep in mind that the time needed for a repair can also vary depending on the repairman. It's the right colour and it seems to be within normal range. Retorqued tanny cover bolts. Today I was driving about 25mph and the engine started revving but the transmission wasn't getting a good bite. The time needed for your particular repair may be different. It's still under warranty and ford is now in the process of deciding if they will rebuild ($3800) or replace ( (>$5000 . How to do a Ford throttle body relearn procedure. Now in October 2012, the second transmission as the service member said at the Ford dealership "the transmission exploded, we're not even sure how you were able to drive this vehicle. The driving position, which . 2005 ford 500 132k miles Quick fix for minor power steering fluid leaks, See all videos for the 2005 Ford Five Hundred. 2005 Ford Five Hundred Edit Recalls Near 00000 Good News: Your Car Has No Safety Recalls Stay up to date for safety recalls that might affect your vehicle. Est. Clean and reinstall pan along with new filter, refill with new fluid. I then contacted the parent company FORD, asking who I should take my vehicle to for diagnosis without the idiot codes. I'm having some problems with my 2005 Ford Five Hundred (6 speed automatic). Ask. Ford issued a recall for the affected vehicles and offered to replace the CVT free of charge. Search by VIN. Transmission failure, sudden loss of power. There have been times when a trans replacement is the only proper repair only to be scrutinized by. Many have no transmission dipstick, I assume your car has one. P0193 - Fuel Rail Pressure Sensor A Circuit High. The next day the warning lig.. Thanks in advance for any and all help. Will repair myself. The video above shows where the transmission fluid dipstick is located in your Five Hundred and how to check the transmission fluid level. I suppose I will have an transmission failure soon to come. Source: www.familyautoofgreenville.com. I dont really think that the customer has the option here. Get the best deals on Automatic Transmissions for 2005 Ford Five Hundred when you shop the largest online selection at eBay.com. I had considered a new Fusion, but no more. This was my first Ford and it's now my last. very dangerous.ford plz recall this transmission problem (defect) before someone is injured 2005 Ford Five Hundred 126,000 mi, Visitor See .. The transmission check plug will typically be on the bottom or the side of the transmission and may also be next to the axle. Remove Transmission Fluid Cap / Dipstick - Access point for transmission fluid, 4. Is this safe? New comments cannot be posted and votes cannot be cast, Press J to jump to the feed. New (factory OEM rebuilt) transmission installed, also required a transmission mount to be replaced (mount broke due to hard shifts). The CVT also works with the engine control system, including the electronic throttle, to find the best compromise of torque, fuel efficiency and emissions. In most cases, the repairs will be covered by the manufacturers warranty. . They seem to be sensor codes, but I understand the sensors are within the unit. If you still have any questions, feel free to comment below. These are just two examples of the consequences of driving with a recalled transmission. However, I would be remiss if I did not mention that when I checked it, the car was off (it was warm, but off) and the surface may not have been entirely level (it's really difficult to find a nice level place where I live and I have not been comfortable driving it much). I had the front brakes and caliper replaced in November and since then my awd malfunction appeared and anti skid light also came on. The next day I made a 500 mile drive to, around, and back from Savannah, GA with no problems. 55800 mi C $350 Driving with a recalled transmission is extremely dangerous and could result in death or serious injury. I hear ya, and except for the fact that I lost my sis and she left the car to me, I'd be doing exactly that. Looking for installation procedure. Authorized dealership, said nothing was wrong with the vehicle after they scanned it. I took my car to a mechanic because the check engine light was on. Transmission shifting poorly, full transmission fluid flush done. Cleaned the throttle body , no change - $150 charge . Ford offered the AWD with CVT when they re-introduced the 500 in 2005. Cost to replace mount by dealer is close to $500. Edit: I usually drive it like a grandpa, maybe it just needed some zoom-zooms. However, there are some general guidelines you can follow to get an idea of how long your particular repair may take. I now have a lump of steel sitting in front of my house. I can't even use it as a demo derby car. It feels as if the vehicle can't decide what gear it wants upon acceleration, it bucks back and forth sometimes trying to choose a gear. For the 6 speed auto trans the dipstick is located behind the radiator support, to the left of the air cleaner box. Is it a viable/better option to replace with the 6-speed auto? Its still under warranty and Ford is now in the process of deciding if they will rebuild ($3800) or replace ((>$5000) the CVT. Clunking noise in transmission when accelerating Dealer will look into when they replace the seat cover on the driver's side. Transmission fluid levels seem ok, but I'm not great with car, so I could be wrong. Why hasn't Ford been forced to replace this transmission for all of the 150 complaints listed on the website? . I need to change the ECT sensor, don't know where is it in the Ford 500 2005 can you please help me. They should be replaced with revised brake pads, and all wheel drive (AWD) vehicles should replace front brake pads as well. @media(max-widt.. The VIN was unknown. He said it was a throttle control sensor or check sensor, or something along those lines. Will bring back to dealer for diagnostics. If you try to accelerator during one of these hesistations the transmission engages at a much higher RPM, can be damaged. Use of this site constitutes acceptance of our Terms of Service and Privacy Policy. Durn transmission again, stopped going into Reverse. February 25: Ford Recalls Vehicles Over Loose Transmission Bolts Throttle Body Malfunction 2005 Ford Five Hundred (Page 1 of 2) This problem may be covered under warranty. The contact stated that the transmission was replaced and within a couple of days she drove the vehicle again and it stalled. Also please check out the 4. Get notified about new defects, investigations, recalls & lawsuits for the. There seems to be a problem serving the request at this time. In general, most repairs will fall into one of three categories: minor, major, or complex. If you let the vehicle set or turn the vehicle off, sometimes you can regain some power to move forward but when you slow down and then try to increase your speed the vehicle will come to a complete stop. all problems of the 2005 Ford Five Hundred It had a bad jerking problem when I sped up to fast or slowed down fast. There are two transmissions: a continuously variable transmission (CVT), and a new, six-speed automatic. Would an air/fuel mixture problem possibly cause the throttle problem do you think? Given the difference in price, Im assuming theyll go with the rebuilt option and Ill have to escalate to get a replacement. The wrench light came on and the text said "Check Transmission", this has never happened before. After reading all the complaints and issues, why hasn't something been done? In one case, a woman was driving her car with her young daughter in the backseat when her transmission suddenly failed. Ground straps can be added to help prevent future corrosion of components. Some years back I bought a 1990 Ford Aerostar from a used car dealer but it had some factory warranty remaining. See Vibration between 1200 and 1500 rpm. Once above first gear at high speed the tranny seems to work ok, but has a slow response time. breadcrumb. This has a CVT Transmission for an all-wheel drive vehicle. The wrench symbol light is a warning light for the electronic throttle control system . and The Ford Five Hundred was the first full-size Ford sedan to feature a folding rear seat to supplement the 21 cubic foot trunk (larger than the Lincoln Town Car). If you shop at Amazon.com (for anything), use this link to support FordTaurus.net! I asked the service manager why they just didnt hone the cylinder wall and he said that Ford wouldnt allow this. If you try to accelerator during one of these hesistations the transmission engages at a much higher RPM, can be damaged. Vehicle, went into a "creep mode" immediately following one of the instances, but the computer reset itself after several minutes. Whenever major transmission repairs are made, it is important to be sure the PCM and the TCM have the latest software updates to help prevent these issues from reoccurring. Enter a VIN to learn if a specific vehicle needs to be repaired as part of a recall.